Mk1 buying
How to read the VIN sticker
VIN sticker in boot
zzz are spacing letters.
53 is the VW type number. eg. Beetle=type 1, Polo=type 86, Scirocco=type 53.
z is another spacing letter.
E is the year of manufacture. eg. 1980=A, 1981=B, 1882=C, 1983=D, 1984=E.
K is the place of manufacture. eg. Wolfsburg=W, Emden=E, Karmann of Osnabruck=K.
012345 is the body number.
Line two has the full type number and sales code.
534 is a RHD Mk2 Scirocco. 531=LHD Mk1, 532=RHD Mk1, 533=LHD Mk2.
C34 is the Storm sales code. This is not used for any other Scirocco. A good way to check if your car is a real Storm.
Line three has the engine and gearbox code.
DX is the 1.8 injection petrol engine. 4Y is the 5 speed manual sports gearbox
Line four has the paint and interior trim codes.
LK5Y is Cosmos blue metallic. 95 is the blue leather interior.
The bottom numbers are the options included. eg. 560 Steel sunroof.
527 Passenger side interior adjustable exterior mirror. 719 Storm extras.
Mk1 Scirocco buying guide pt2
Suspension and steering
Mk1s on test track
Suspension consists of Macpherson struts with wishbones at the front and trailing arms at the rear. Springs can snap is rusty and the dampers are oil or gas filled. Make sure the formers are not leaking. Check the suspension top mounts for signs of fatigue, if they are hard and brittle and the car crashes on bumps then its time to replace them. Rear top mounts have a much easier time and very rarely need replacing.
The suspension can be invigorated by replacing the top mounts and the wishbone and rear axle beam bushes. The bushes do have a shelf life and take a lot of punishment. Replacements are cheap and wishbones can be purchased already bushed, otherwise a press is required to remove and refit the wishbone bushes. Rear beam pivot bushes will always require a press to replace them. Bushes can be upgraded to poly replacements if originality is not hugely important.
Steering should be light and precise and it is worth checking wheel alignment and tracking before consigning the rack to the bin. The rack itself is long lasting but if steering is sloppy it may need replacing. Steering rack mounting bushes can also perish and will benefit from being replaced. No Mk1s left the factory with power steering.
Fueling
Petrol consumption figures are quite frugal, even in the injected models. 35mpg is easily achievable, meaning not much of a headache at the pumps. All Mk1s will run on unleaded petrol. Most owners recommend putting super unleaded in these older cars as the higher octane rating is kinder to the engines.
When buying a Mk1, always try to ensure that the car is started from cold. If it hesitates to fire up and idle smoothly during warm up suspect the carburettor or on injection models the cold start valve (5th injector). On carb models the original auto-choke Pierburg or Zenith units can become troublesome with age and many vehicles have had their replaced with the simpler and more efficient Weber carburettor with a manual choke. Both carb and fuel injection models should idle at around 900rpm once past the warm-up period. Misfiring on fuel injected cars is more likely to be tired spark plugs or faulty HT leads rather than injection system problems.
Throttle response should be smooth and without resistance -if it isn’t smooth inspect the condition of the cable and the mechanism at the carb or throttle body.
The weak link of the mk1 fuel sytem is the metal filler neck which runs from the rear quarter to the tank. Due to the proximity of the wheel arch this area is a notorious rust trap as the rear wheel throws salt and muck and road debris against the filler neck enabling corrosion to take hold and eventually pit the neck with holes, leading to contamination of the fuel. › Continue reading
Mk1 Scirocco buying guide pt1
TS -pre launch '73
Introduced in 1974 and based around the floorplan and mechanicals of the Volkswagen Golf, the handsome Scirocco coupe was actually launched six months before the Golf to iron out teething issues before commencement of the high volume hatchback. More details found in the design history article.
Specification
The first incarnations of the Scirocco were driven by the new VW/Audi 1571cc overhead camshaft engine coupled with an all-synchromesh 4 speed gearbox or 3 speed automatic driving the front wheels and fuelled by a carburettor. Like other German cars of the 1970s, Sciroccos were relatively well equipped, the first 1974 TS models sporting 13″ alloy wheels, quadruple halogen headlamps, twin two speed wipers, reversing lamps, rear heated window, reclining front seats with integral headrests, full carpeting and a centre console all as standard specification.
In mainland Europe, the Scirocco was also offered with VW’s smaller block engines, initially the 1 litre unit and later the 1.3 engine. Externally these cars are identified by large square rectangular headlamps rather than the quad round lamps and 13″ steel wheels. These are few and far between these days.
For October 1975, the engine capacity had been increased to 1588cc and for aerodynamic reasons the twin windscreen wipers were replaced with a distinctive single arm that swept the entire screen. This would be a Scirocco feature and be carried over into the early versions of the Mk2.
In October 1976, for the 1977 model year, the TS was replaced by the GLS. The GLS was mechanically identical but featured interior and trim revisions of vinyl and cord upholstery (replacing the tartan of the TS), part carpeted door cards, laminated windscreen, tinted windows, standard rear wash/wipe and revised control stalks, steering wheel and ventilation system. Externally the GLS carried a plastic front spoiler.
'76 GTI
A year later major external revisions were made to the indicators, wrapping them around the front wings and the addition of plastic bumpers that reached the wheel arches (replacing the chromed metal units with thier shorter end caps) and black B-pillar trims. On the continent, the exciting new fuel injected version Scirocco, the GTI, had been released and was available as a left hand drive import in the UK until the right hand drive version arrived in 1979 known as the GLi.
The GLi was powered by the same 1588cc fuel injected engine found in the Golf GTi and was reckoned to be as good, if not better than the Golf, due to the Scirocco having a lower centre of gravity and a more slippery shape. The 1979 GLi was joined in the UK by another fuel injected model, the Scirocco Storm that was a top of the range model featuring leather sport seats and door cards, plush carpeting that continued into the boot and a black instrument panel. Externally it was identified by flatter versions of the GLS alloy wheels and a large front fibreglass airdam. Both GLi and Storm also featured the GTi front ventilated brake discs. 1979 also saw internal revisions for the GLS, replacing the seats for cloth covered versions with headrests and revised patterns. › Continue reading